Известка / Primitive Technology :: видео (video)

Primitive Technology видео 

Известка


Подробнее
Primitive Technology: Lime,People & Blogs,,At the old hut site (the new one being temporarily cut off by flooding) I made lime mortar from the shells of rainforest snails by firing them in a kiln, slaking them in water, mixing them into lime putty. Limestone is basically calcium carbonate (CaCO3). The general source of lime is limestone and various other calcareous minerals, though shells, egg shells and coral are other sources of lime. When heated above 840 degrees Celsius, the lime decomposes into calcium oxide (CaO) or Quicklime and releases carbon dioxide (CO2). When water is added to the quicklime it becomes calcium hydroxide Ca (OH)2 or lime putty. From here the calcium hydroxide can then be shaped into a form and allowed to set. Carbon dioxide enters the lime putty as it dries causing it to turn back into calcium carbonate. The new calcium carbonate has then set, remaining solid and water resistant. In my local geography, calcareous rocks such as limestone are absent leading to a difficulty in acquiring the feed stock for lime making. However, I was still able to make lime by collecting the shells of large terrestrial snails that are native to the rainforest here. The unoccupied shells of these snails were gathered up and stored at the hut. Fire wood was gathered and packed neatly into the kiln. Importantly, the firewood was stacked on top of the grate rather than underneath it in the firebox as is the normal procedure for firing pottery. Using an ordinary updraft pottery kiln in this configuration allows it to reach much higher temperatures than would be possible during normal use. The wood was lit from above and the fire burned down towards the grate. Alternate layers of shells and wood were added on to this burning fuel bed. After adding the last layer of wood to act as a “lid” to prevent heat loss from above I left the kiln to finish on its own, unsupervised. The whole process took about an hour and a half. When the kiln had cooled down a few hours later, I took out the calcined shells. Not shown in the video was the fact that some shells got so hot, the dirt stuck to them turned into slag and fused to them, possibly with the lime acting a flux lowering its melting point. This extreme heat (+1200 c) should be avoided as the over burnt lime becomes “dead lime”, unable to slake in water. Most shells were still useable though. They were taken out of the kiln and had water added to them. An exothermic reaction then ensued. Heat was produced as the lime quicklime turned into slaked lime. The water heated up creating steam and the shells decomposed into a white paste. The paste was stirred and crushed pottery was added to it as an aggregate (sand is normally used for this, I just had a lot of old pot sherds lying about to dispose of). This lime mortar mixture was then formed into a block shape and left to dry. It took about a week and a half to set as we have had extremely humid, wet weather. The block was observed to have set demonstrating its properties. What I created is actually lime mortar, typically used for mortaring bricks and tiles together. It’s basically the ‘Glue’ that holds together the building blocks of masonry structures. From my research 20 kg of lime mortar is used on a 1 m square section of brick wall. 5 kg of lime to 15 kg of aggregate (sand, grog etc.) per a 1 m square section of bricks. The shells, though large, are not terribly abundant. A method for finding shells efficiently needs to be made before considering making lime mortar in this fashion. From my experience sand bars in a creek sometimes accumulate snail shells from higher up in the mountains. In these spots, water velocity decreases and shells in the water tend to drop out of the water column. Additionally lime may be partially replaced with ordinary wood ash in mortar without a corresponding decrease in strength. To conclude, making lime in a land without limestone is possible but can be problematic when trying to do so on a large scale.
Primitive Technology,видео,video
Еще на тему
Развернуть
эксклюзивный хенд-мейд кирпич
Nemul Nemul 07.03.201804:00 ответить ссылка -0.8
вот еще один товарисчь изготовляет эксклюзивный хенд-мейд кирпич

всё бы хорошо, но вот его шкрябанье ногтями по кирпичу это полный пиздец, аргх
На 15 минуте. Для любителей особых ощущений.
Только ради этого открыл, спасибо. Буду спать под этот ASMR.
Хендмейд бетонный блок.
Схерали жареные ракухи в воде дымятся?
yans yans 07.03.201804:16 ответить ссылка -7.4
вероятно реакция с водой
Ракушки - это галимый кальций. Благодаря огню они становятся CaO - известью. А известь, как известно, отлично гасится водой. CaO+ H2O = Ca(OH)2. То есть гашеная известь. Потом он её будет использовать в своём строительстве.
всегда удивлялся и щас тоже, как это у него получается из 2х палок развести огонь, я сколько не пробовал, у меня не получается, я и зажигалкой буду дольше чиркать чем он палками.
может палки какие-то особенные и у нас не растут? кто пробовал палками разводить огонь? получалось? из каких палок?
Обычные сухие палки и обычный сухой мох
В школе нас ОБЖшник так учил огонь разводить, обычные сосновые палки использовали.
Меня же больше удивляет что он уже сделав приспособу для механического розжига продолжает тереть руками.
iggd iggd 07.03.201806:35 ответить ссылка 1.4
Он вроде упоминал что он так часто разводил огонь руками, что ему уже так проще и удобней
А ещё говорил что он лучше будет разводить руками, чтобы навык не терять
Nik790 Nik790 07.03.201808:47 ответить ссылка 1.4
Бля, он умеет разговаривать? О_О
Но не все знают, как послушать.
похоже он все умеет
Heralt Heralt 07.03.201811:16 ответить ссылка 0.5
остается только развести руками
jabia jabia 07.03.201810:33 ответить ссылка 0.7
Wolh Wolh 07.03.201815:34 ответить ссылка 0.9
Он разговаривает!?
gumanist gumanist 07.03.201808:54 ответить ссылка 0.3
А тут уже дом из таких кирпичей строят

Voler Voler 07.03.201808:56 ответить ссылка 3.0
Этож сколько ракушек...
Да по-тихому в магазине купил. Это то же самое, как жрет Беар Гриллс за кадром.
Этож вроде другие, у них даже шорты чёрные
Ну эти известняк обжигают, которого под ногами валяется дохренища. Белые такие камушки, многие их могут помнить по железнодорожным путям, когда кидали их в вагоны проезжающих составов. По крайней мере я из своего детства помню известняковые камни именно по этим эпизодам.
Так что набрать этих камней пару десятков килограмм и обжечь за пару дней - это не так уж и сложно. Просто чувак из сабжа или выёбывается в "о, я примитивный человек, я ещё не знаю об этой технологии", или на его острове просто нет известняка.
Жалкая пародия
Сраные дикари - в лесу живут, пням поклоняются.
842690 842690 07.03.201809:17 ответить ссылка -3.2
Зачем они это делают?
им это нравится
Это эксперимент такой
Чтобы показать, что предки были не тупые и могли без инопланетян/атлантийцев/богов/котиков строить дома и делать инструменты с посудой
Но у них не было интернета. Или был? Интернет, который им привезли инопланетяне. Не эта ли утраченная технология предков, о которой говорят в легендах?
Информационное поле земли.
Только зарегистрированные и активированные пользователи могут добавлять комментарии.
Похожие темы

Похожие посты
Primitive Technology: Thatched Workshop,Science & Technology,Primitive Technology,Thatched Workshop,thatched,workshop,primitive tech,primitive technology building,primitive technology hut,hut primitive technology,primitive technology workshop,workshop primitive technology,work shop,primitive
подробнее»

Primitive Technology video

Primitive Technology: Thatched Workshop,Science & Technology,Primitive Technology,Thatched Workshop,thatched,workshop,primitive tech,primitive technology building,primitive technology hut,hut primitive technology,primitive technology workshop,workshop primitive technology,work shop,primitive
Sweet potato patch,People & Blogs,,I built a fenced enclosure and cultivated sweet potatoes (from civilisation) and yams (from the wild) in it. I originally had a small 3X3 m garden behind the wattle and daub hut that already had some sweet potato and yam vines growing in it that were planted after
подробнее»

Primitive Technology видео,video

Sweet potato patch,People & Blogs,,I built a fenced enclosure and cultivated sweet potatoes (from civilisation) and yams (from the wild) in it. I originally had a small 3X3 m garden behind the wattle and daub hut that already had some sweet potato and yam vines growing in it that were planted after
Primitive Technology: New Brick Kiln Design
подробнее»

Primitive Technology видео,video

Primitive Technology: New Brick Kiln Design
How to make a Chinese herbal honey? 长白山人参蜜:众参皆苦,而我是甜的,Howto & Style,liziqi,Lý,Tử,Thất,中国风,Chinese girl,Chinese food,李子柒,美食,中国美食,饮食文化,传统,生活方式,参蜜,长白山人参蜜,给生活来点甜头。来自于长白山的人参蜜,用的是4-5年种植人参、平均70年树龄椴树花蜜精心制作,29道工序过后,甜味和香味会显得浓郁一些,温和不易上火。一年四季都可以吃,给生活来点甜头。
подробнее»

Primitive Technology не Primitive Technology Китай страны видео,video

How to make a Chinese herbal honey? 长白山人参蜜:众参皆苦,而我是甜的,Howto & Style,liziqi,Lý,Tử,Thất,中国风,Chinese girl,Chinese food,李子柒,美食,中国美食,饮食文化,传统,生活方式,参蜜,长白山人参蜜,给生活来点甜头。来自于长白山的人参蜜,用的是4-5年种植人参、平均70年树龄椴树花蜜精心制作,29道工序过后,甜味和香味会显得浓郁一些,温和不易上火。一年四季都可以吃,给生活来点甜头。
Primitive technology: A frame hut,People & Blogs,,I built an A frame hut as a large work space for projects. First I made a celt hatchet to cut timber for the hut. The axe head was made of amphibolite and the handle was made of a species of wattle. For the hut the floor plan was 4 X 4m. The height
подробнее»

Primitive Technology видео,video

Primitive technology: A frame hut,People & Blogs,,I built an A frame hut as a large work space for projects. First I made a celt hatchet to cut timber for the hut. The axe head was made of amphibolite and the handle was made of a species of wattle. For the hut the floor plan was 4 X 4m. The height